|
The
Granddaddy of all refits And finally the
update is done which can only mean we’re back in the cruising mode and
about to head off. Or have already done so… It has been a long 18
months, lots of work on Hannah, lots of paid work for Bee, less for me,
but sat over the inevitable evening glass of wine (now home brewed) there
is a feeling of satisfaction at the changes we have made, improvements
all. Engine and gearbox sorted, doghouse built, new sails with the
addition of a trys’l and small storm stays’l (NOT
that we will ever need them….) and so on. Here’s a brief rundown on
the efforts to date. We came out of the
water on Dec 4th 2005 and built a “Maine shelter” to
protect us from the, forecasted, harsh winter. The building process was
accompanied by
One of its great
assets was it enabled us to get on with work as it tended to hide us from
passers by and although work progressed slowly we were moving forward. Of
the many jobs we had to tackle the repairing of various bits of hull
damage was fairly prominent. Long time readers will, perhaps, remember the
stories of hitting lumps of French granite and being assaulted by a
runaway iceberg. The latter was relatively easy as the damage was confined
to the epoxy that had been used to fair the hull. The granite damage
proved a different problem as the cement we had used had set so hard it
refused to crack with a lump hammer and bolster and eventually we gave up
and decided it was sound enough. We ground it back to give a smoother
finish and declared ourselves satisfied. The wonder of concrete hulls….
And the wonder of the use of the shower on Larus (Tim and Nancy’s boat)
to rid ourselves of the inevitable cement dust that accompanies the
grinding back of the hull. Their purchase of a flat couldn’t have come
at a more timely moment either and they may never fully understand our
appreciation.... Other tasks we came across were rot in the bridge-deck
and the bottom of the mizzen and touches of rot in the main. All repaired
with varying degrees of difficulty. “Stan” became the focus of our
attention as we bombarded Paul with numerous changes we felt we needed –
almost entirely to stiffen up and make it more storm proof. The re-launch day
came and went without us and we settled for a more expensive sole
launching later in the year. We
contacted a supplier for Jotun paints, checked the colour on the internet
and were suitably horrified when we opened the tins to confirm…going
back to the internet we noticed a small notice which indicated that
colours shown on screens, because of the limitations of computers, bear
little resemblance to reality.
Well ok it wasn’t
quite like that but certainly the gist. Reactions varied from “the
contents of a babies nappy” to a “great colour to be seen at sea”
with us firmly in the latter camp. By May, with the sun high, we needed to
remove the cover as temperatures would easily rise to 30ْC
and above and even the tomato plants Bee had elected to grow seemed to
wilt under the heat.
We completed the paint and bright work, cleaned up the engine, replaced, with Geoff’s help, the timing belt and re-fitted the engine. By late July we were back in the water and towed back to our berth. Engine was re-connected, prop shaft and a new flexible stern gland fitted and with new wiring we fired it up and did it run well. All that thanks to John of course.
Smaller jobs were completed and then we got a surprise visit from Martin and Roma in “Apple” a steel Wylo, their latest build (and last they assure us) Lots of neat ideas and high workmanship and great to see both boats together.
Actually we have had
several visits whilst here. Ziggy and Lisa and then Stephen and Zella both
visited, at different times, from the US and then my grandson Evan arrived
towing his parents, Pete and Sarah, along to see the reprobates in the
flesh. Quite a year!
By now we were almost, we thought, ready and then idly glancing through an oldish copy of Yachting Monthly I happened to see a photo of a similar boat to Hannah that had built a doghouse………………… YES just what we needed!!!…….much discussion with many different people, a pooling of ideas and then the break we needed when Alastair casually mentioned he’d love to give me a hand in the build. Alastair, besides featuring in a number of previous webpage’s of ours is also a dab hand with wood and his offer meant the difference between “Gawd what on earth is that” and ”It looks like it has always been there”.
We measured, cogitated, re-measured and
then ordered. I collected from the wood yard but was absolutely gob
smacked at the size of the timbers and had a nervous chat with my mentor
about the sizes – surely Noah couldn’t have had anything like these
sizes? But we worked on steadily, me looking on, AD whittling away and
slowly it came into being and, I have to say, is everything we could have
wished for. The timbers are in keeping with the massive strength of Hannah
and already we appreciate the difference as ventilation improves
dramatically, the blessed Toots has somewhere to shelter and rain no
longer means we have the hatch slammed shut.
The sails! Well this
was a saga that could have been from hell. We’d bought the material,
found an industrial sewing machine and a copy of “The Sailmaker’s
Apprentice” A local hall was available for hire (Ł6.00 ph) and a mental
(you choose which way it’s meant..) calculation of 200 hours to cut and
stitch seemed about right. The weeks turned into months and Bee’s
reminder that we (I) hadn’t started was met with excuses. Finally we sat
down to work out a strategy which quickly established that perhaps we
should give ourselves a head start and get the main made. I phoned around
to find a sailmaker who would use our material. All I spoke to said
“No” but many mentioned the name “James Lawrence” and so I rang.
“Sure, No problem” After a couple of discussions with Mark Butler at
JL we felt that perhaps we should just hand the whole job over and so
drove over to Essex with our old sails. Watching the loft in action made
us realise that we had been out of our depth here and the relief at
handing the job over was palpable and enormous. Made more so when we told
the sails we had asked for, 9 in total, would take 3 skilled people 3 –
4 weeks to complete….perhaps I needed to add a 0 to my calculation of
200 hours? Readers of earlier entries may remember our uncanny ability to
find heavy weather whenever we’re “doing a long one”. It’s this
ability that we focused on when we were discussing the sails with Mark and
the reason we now have deeper reefs in both the main and mizzen and a
trys’l and storm stays’l for those moments when the call of the sea is
replaced with the call of the 9-5…………. As yet we have had little
chance to try them out other than for a few hours but we’ll report in
due course. Another change has been the saloon stove. Battered and worn the old one had given great service but we’d set our heart on something with a little more control, something that would burn through the night if required and chose to fit a Morso Squirrel
It is a cracking
stove, fulfils all our needs and with its glass front gives a wonderful
glow. We toyed with the idea of a back burner and radiators but then found
we’d need to install a pump and then we’d be into additional power
requirements. (The pump used by Reflex uses about 2 amps!). KISS… A tale or two….
I’m in the engine compartment, clarting around and Bee is putting the
kettle on. As you are possibly aware we have a Taylor’s Paraffin Cooker
which is preheated before igniting. Bee was in this preheat process and
turned to the fuel tank to pump up the pressure, turned back and was
confronted by a small wall of flame. “I think you should come here”
sayeth the dulcet toned one……….:”I think you should come here
NOW” It was the slight emphasis on the last word that alerted me to the
fact that something might be amiss………. We dumped a fire blanket over
the flames, blasted it with an extinguisher and retreated up top. Gazing
at the white fire blanket I could see a cherry glow and a gentle roaring
sound and rushed down the companionway. Peeking under the blanket, holding
my breath against the fumes I can see the fire is definitely not out. In
one of those strange coincidences in life Bee had come back from Asda the
night before and announced that the shop had fire extinguishers and, as
ours were mostly out of date, perhaps we should get a new one. Oddly
enough instead of prevaricating as I usually do we had gone in that
morning and bought one. And, of course, it was this brand new extinguisher
I’d grabbed and squirted over the blanket. This time I lifted the
blanket and emptied the remains of the contents across the
cooker…………. Well they do make a mess but more importantly they
work very well. Obviously we
needed to replace that and buy more but timing is all it seems. The fault
by the way can be traced to the eejit I employ to keep the cooker in fine
fettle i.e. ME. I had allowed a locking nut to work loose (or more likely
not done it up tight enough) which had allowed a fuel leakage and then the
fire. Paraffin is a MUCH safer fuel than gas and has in no way altered our
view of the cooker. Other than to make sure all necessary work is done
properly and in good time. And then one day passing the rubbish bin, as
usual full to overflowing, I spotted a wine box lying on top of the rest
of discarded items. Ever curious I shook it and was rewarded with a carton
at least half full….as a matter of academic interest I checked the sell
by date and startled to see it was only the day previous. Of course we
drank it – kept us going for several days. We had a week away, ostensibly as a shakedown and or departure. Motored across to Newtown Creek and then endured a week of howling gales as low after low came scudding down the English Channel. At one time we suffered a whiteout as wave tops were blown clean off and when the wind backed to the SW we had a fine time…………. Except that it reminded us rather more than we wanted of the journey back from Greenland…………………
With the many nights we
have spent at anchor over a variety of seabed’s you will appreciate how
dear to our hearts a good anchor is. We’d used a 45lb CQR and a 56lb
imitation CQR and whilst the heavier one was much better we were aware
that in very strong blows, despite a long scope and a religious fervour
when setting the damn thing, Hannah had a tendency to creep. By creep I
mean that the wind and wave strength would combine to gradually move her
across an anchorage, despite being, apparently, well dug in. It might only
be 60 feet or less but it happened. It may be the effect of tide or wind
changes but it happened. Where the anchorage is wide and loads of sea room
it isn’t a problem but it is something else we have to concern ourselves
with. Over the years we had become almost fanatical about our anchoring
technique and would set and reset if we had doubts about the holding.
Better to do it then than face a gale and a dragging hook. Then we read
about an anchor that seemed too good to be true. Sets first time (another
bone….) and just keeps digging in.
Intrigued we contacted the Kiwi company and did some more research
and then decided to buy. This time we have gone larger still (33kg or
73lbs) and the short trial we had in Newtown has so far confirmed we made
a good choice. It set first time on the 3 occasions we dropped it and set
it that wonderful, heart warming way that forces the boat to swing
immediately toward the anchor, irrespective of the way she is falling off.
Yes, I know Newtown is a good holding and that the anchor is heavier than
those we have used before but with our experience to set as the ROCNA did
and for Hannah to sit without any creep, on a short scope, when the wind
strength was so high is unprecedented. We look forward to trying it out on
a variety of beds. Watch this space.
The future……… Vague, as ever.
Initially we’ll head west to Cornwall and then up the Irish Sea via
Wales to Scotland. We’re thinking of heading across to the west coast of
Norway and onto the Lofoten Islands before heading south via Ireland to
Madeira and the Canaries and across to the Caribbean. Not all in the same
year of course. So the best we can say is that 2007 should see us in
Scottish waters. The winter? Dunno. And finally our
heartfelt thanks to a whole bunch of people who have made the last 18
months so much easier. As ever generosity with showers/help/equipment and
work (and in that order….) made our lives that much more bearable. We
thank you all. |
